04-25-2021, 09:49 PM | #1 |
Enlisted Member
7
Rep 48
Posts |
ZF8 Rough Shifting
I've recently starting noticing some rough shifts from my ZF8, primarily in the lower gears and at low speeds. After shifting to the next gear, it feels as if it's not completely engaging for a split second, during which the car cuts power. I'm at 85k miles and haven't done a transmission fluid change, and the car was shifting perfectly until a few days ago. I also don't have any codes. I thought it was my JB4, but turning it off doesn't help. The only other thing I can think of is something with the MAF sensor since I have a Mishimoto intake, but again there hasn't been a single CEL. Here's a YouTube clip for reference:
Any idea what could be causing this? |
04-27-2021, 04:56 AM | #2 |
First Lieutenant
70
Rep 360
Posts |
Following for curiousness.
Have you tried resetting adaptions on the gearbox? Ista should show current setting of the clutches etc. Then you could reset. I've done this on mine as my first gear change is always a little harsh. |
Appreciate
0
|
04-28-2021, 10:56 AM | #3 |
Enlisted Member
7
Rep 48
Posts |
I've been shying away from getting ISTA, but I'll give it a try if all else fails. I was thinking it might be an air fuel issue since even in neutral/park it idles rough and feels like it may stall at times.
|
Appreciate
0
|
04-28-2021, 12:35 PM | #5 |
Brigadier General
4075
Rep 3,203
Posts |
|
Appreciate
0
|
05-01-2021, 05:30 AM | #6 | |
First Lieutenant
70
Rep 360
Posts |
Quote:
The kits are relatively cheap, but make sure you use ZF8 oil. |
|
Appreciate
0
|
05-04-2021, 02:17 AM | #7 |
Registered
0
Rep 3
Posts |
I was actually just going to post about my ZF8 being jerky. It seems to be rough on gears 1-3, especially when cold. Once it warms up it seems to be fine. I don't know if it is normal for me either. I changed the fluid and it was then very smooth. After some time though, it changed back to being jerky. But changing the fluid did make it less jerky than before.
|
Appreciate
0
|
05-13-2021, 04:19 AM | #8 | |
First Lieutenant
70
Rep 360
Posts |
Quote:
|
|
Appreciate
0
|
05-13-2021, 04:31 AM | #9 |
Captain
513
Rep 749
Posts
Drives: F31 320d xDrive M Sport
Join Date: Jul 2020
Location: West Sussex, UK
|
Mine was never rough, but after getting the ZF oil & filter/pan replaced (at 80k miles), it was so silky smooth.
I'd suggest a gearbox service.
__________________
|
Appreciate
0
|
Post Reply |
Bookmarks |
|
|